The noise is an intermittent clunk which is not felt through the steering wheel. They did however, change the nearside front linkage assembly the previous week. When your car develops a clunk or rattle when going over bumps in the road or starts to make an odd sound when driving, often the biggest issue is identifying which drive or suspension component is causing the noise so you can replace it. Either way, worn out or damaged control arms can cause the wheels to move out of alignment, producing a clunking noise going over bumps. 0. If we are on a gravel road, the nose is horrible. The bushings provide a cushion for the suspension and help to reduce NVH (Noise, Vibration, & Harshness). Sometimes the small rubber gaiter which protects the ball joint is perished letting dirt in. Dealership changed right side sway bar (left driver side inspected and said is okay), changed strut mounts and . The van sounded great on the highway, but . ford: some 2013-2015 ford c-max, 2013-2015 ford escape, and 2012-2014 ford focus equipped . For example, an old parking lot, or the washboard on asphalt roads near 4-way stops. Only show this user. A damaged control arm will cost $160-$390 per arm. Less common causes are bad axle, worn suspension or steering parts or incorrect tire pressure. Eddie Carrara. I'm no car mechanic but any guesses as to what it might be are welcome - so at least I don't sound . 2010 Ford Focus. Same issue, 2015 F350 80,000kms on it. Join to talk about performance, specs . Ford Fiesta Zetec knocking/clunking. Clunky noise when turning and driving over bumps Suspension | Chassis | Brakes . 1.3L V6 2WD AUTOMATIC 153,000 MILES Clunking noise coming from front end while going over bumps. MODEL 2012-2013 FOCUS, ESCAPE. 86 Mercury Capri GS 2.3L 11 Ford Ranger XL 2.3L 10 Ford Focus SE 2.0L 17 Years of Foureyedpride.com . Loose wheel and tire lug nuts ; Damaged or loose tires; Worn, damaged, or leaking shocks or struts ; Loose, worn or damaged upper control arm or upper or lower ball joints ; Worn, loose, corroded, or damaged outer and inner tie rod ends or power steering rack ; Loose or damaged wheel bearings Sorry to start up an old thread again but I have the same problem as posted. To test, jack the car up with both front wheels off the ground.This leaves the droplink unloaded. The aggravating thing about this was that I could not reproduce the issue upon command in preparation for a dealer visit. Read more Popping or clicking noise from middle of vehicle. Sway bar links usually make noises while cornering. Red Wifey's econo box:thumbsup: . I jacked the car up last night and tried to recreate the sound but was not able to come up with anything. Prices may vary depending on your location. Hi there. 26/03/18 - 12:09 #1. . Clunking noise HELP. noise. BUMPS. As the title says I have been experiencing a modestly loud clunking noise going over bumps which sounds very similar to bad sway bar bushings for a few weeks now. After just 1000 miles, the front end started making clunking and creaking noises (like an old bedspring) when going over uneven surfaces or turning a hard left or right especially into a driving into a curve. resolving a clunking in front end of a ford tarus 2002 a consistant clunking over bumps. Not so much dips in the road. Have some look at the engine while its under load (easier to do in an automatic) If excessive engine movement is seen suspect a torn/worn mount. 2000 Ford Focus SE.120,338 miles Clunking noise under front end..Sounds more like on driver's side when going over bumps. CLUNK/RATTLE NOISE FROM FRONT END DURING TSB 13-9-9. Front struts, lower control arms and sway bar links wer read more If all the oil leaks out, this strut will start to make a knocking noise over bumps and cause excessive tire chop. Another potential cause for clunking is . C $154. when going over bumps or drains, and only at over. Jump to Latest Follow . Tie rod replaced on left side. - Troggy. how the birds got their colours script. . I can just slightly feel it in the floor board, too. . clunking sound when going over bumps rear. Had it in to the dealer the other week for this, they tightened the front sway bar, and the cab bushings. I have a 2009 Ford Flex Limited AWD with almost 55,000 miles on it. The first is kind of a clunk from the left rear when going over bumps in the road where the suspensions compresses significantly. even over steady road driving it's has a squeak to it. Any ideas? FRONT OF VEHICLELOW SPEED TURNS AND. As the title says I have been experiencing a modestly loud clunking noise going over bumps which sounds very similar to bad sway bar bushings for a few weeks now. I've got a knock/clunk from the rear whist going over speedbumps in my mk3. Posted on 3/12/2021. Sorry to start up an old thread again but I have the same problem as posted. Is it just a single "clunk" noise each time or does it does it multiple times with each occurrence? I have had several of these fail on my old Mk1 and they make just the noise you describe. Description: FORD: WHEN DRIVING OVER BUMPS OR MAKING LOW SPEED TURNS, SOME VEHICLES MAY EXPERIENCE SOME NOISES FROM FRONT SUSPENSION, LIKE CREAKING OR CRUNCHING TYPE. Thread . 1. When your car develops a clunk or rattle when going over bumps in the road or starts to make an odd sound when driving, often the biggest issue is identifying which drive or suspension component is causing the noise so you can replace it. After changing ball joint there was a minor improvement but it has returned to normal now after a week. I have had for some time a noise when I go over small bumps (pulling into garage up a 1" lip) at slow speeds. We noticed this very early. Knocking noise from the front N/S suspension when going over quick succesion bumps in the road. . If left unrepaired, damage can extend to your car's body mount, causing noise and vibration in the vehicle's cab. . Clunking Noise. Sounds like the front end is falling out. Some of those bushings include: Hi hopefully someone can help. See all problems of the 2002 Ford Focus . xxiaze. Possible weld issues on the lower control arms can cause the noise concerns and require repair kits for the lower control arms from Ford. Nothing seemed out of order. More noisey when there's a passenger on board. ascruggs Member. about 15 miles per hour; any slower and there is no. Doesn't happen 100% of the time. Average repair cost is $560 at 99,000 miles. Mar 22, 2017 Focus_2012 said: I have started hearing a clunking noise coming from the front end over the last few days and It only seems to happen when traveling 35+ and going over bumps in the road. a clunk when going over bumps is often caused by loose stabilizer links or mounts, there is a tsb regarding noise from the front suspension. Most noticeable when driving slowly. Done under esp from Ford. Speed bumps don't make it happen. jim croce plane crash cause; 0 comments. Yes. It could also be the upper strut mount bearings making the noise too especially if its noticed over bumps. SURFACES AT LOW SPEEDS BETWEEN 8-32 KM/H. While troubleshooting this clunking noise, I did adjust the preload so that the springs are much tighter just to see if the issue was a "coilover clunk" type of thing. Which was caused by the rear suspension not settling and not being aligned. No noise when i'm turning the wheel at / near dead stop (like when parallel parking) It clicks a couple of times going over bumps. Your system should read at -11 to -12 for retard timing. It started out very subtle and only happened when turning at low speeds and gradually started happening more often. 2014/2015 Ford Escape. The bushing is that black rubbery connector inside the metal housing in the middle of the picture. At first I thought it was just the pads scooting back and forth in the calipers when I pumped the brakes, but I noticed it when I go over the little rise in the slab when I go from the driveway into the garage. Also, when weight shifts in the front end - like when slowing suddenly, I hear a slight knocking/thumping/pop that sounds like it does when I turn. . FocusRS.org is the largest forum community to discuss the 2016+ Focus RS. I replaced both sides and the bushings and no more clunk noise Read full answer. sway bars also make noise over eneven surfaces but its more of a sprung pop noise and usually only on one side. drive 95% of the time and theres no noise, just them f-ing red speed bumps make it clunk! Yes. When the get re-lubed and the noise is gone shoots lots of holes in my theory. The main issue is the banging sound. jim croce plane crash cause; 0 comments. On average, the cost for a Ford Focus Clunking noise when I drive over bumps Inspection is $95 with $0 for parts and $95 for labor. Under 2000 miles. Take the wheel off, then try to move the ball joints by hand. But nothing fixed the clunk. 2013 Ford Focus St 2013 Scion FR-S 2007 Honda Civic Si 2003 Acura RSX Type-S 1998 Ford . Also, when weight shifts in the front end - like when slowing suddenly, I hear a slight knocking/thumping/pop that sounds like it does when I turn. Something that may be happening is that daily driving the slip yoke will only move a small amount. Go for brief and careful drive over some bumps. Failure Date: 10/06/2003. It is possible that your vehicle is probably reading around -13 to -14, which will cause the engine. My car has just over . Knocking noise from the front N/S suspension when going over quick succesion bumps in the road. If I hit at an angle, no noise. Manufacturer was contacted by consumer. It sounds like you could have a U-joint failing. I also replaced the driveshaft, which fixed a terrible vibration. It has 133,000kms (83,000 miles). Apr 23, 2014 I have had an ongoing problem with my escape making a metallic clunk and popping noise when turning and going over bumps. While I was in there I lubricated all the rubber with silicone spray. My shop told me it is the lower ball joints. Then I'd think it was something on the rear axle itselfmaybe a loose brake dust shield? 2008 SEL V6 with 70,000 miles on all original parts. 2001 FORD ESCAPE. The dealer has not said a word about it having a TSB. This helps keep the suspension comfortable, quiet, and long lasting. 1. CRUNCHING OR CREAKING-TYPE NOISE FROM TSB 13-5-11. Hope this helps. auto had a noise when going over bumps - replaced . description: ford: when going over bumps in road, a clunking noise is heard. Do you hear clunking, bumping or rattling noises when driving your car or truck over bumps? I wouldn't describe it as a rattle or a knocking, it's more like a squishy, slight knocking noise. Apr 26, 2009 Honda CR-V Cars & Trucks. Join Date: August 2005. Show example Ford Focus Clunking noise when I drive over bumps Inspection prices Clunking noises are annoying and potentially dangerous, and should always be investigated. rear lower shock mounting bolts needs to be checked for sealing and torquing for correct specs and replace, if necessary and knuckle mounting threads cleaned, if there is con . position the jack pad as close to the ball joint as possible. heard. TSB item to replace left strut. If left unrepaired, damage can extend to your car's body mount, causing noise and vibration in the vehicle's cab. I can just slightly feel it in the floor board, too. I took it to the mechanic and had the sway bar links and ball joints replaced and still had the same clunking noise when going over bumps at low speeds. It would only happen in the rear if I hit it dead on. My Fiesta Zetec 2004 1.4 is making a weird noise when I go over bumps. MEMBER. It's a click. If the noise has gone, the culprit was the drop link . Jan 30, 2018. They both can make noises going down the road, but the front sway bar rattling is easier to notice when driving and much more likely to happen. Mine sounds like a strut that is loose. The mechanic believes . 1 comment. It seems to be much more likely when the turns involve bumps or inclines/declines. Likes: M-Sport fan. If the noise has gone, the culprit was the drop link . noise. Put a floor jack under one of the lower control arms. Your Focus may have a rear sway bar as well. 8571 posts. On checking underneath the vehicle, nothing. 66960 mi. So far I changed bottom ball joint and droplinks. As long as you dont drive it hard, it shouldnt be a problem. The car suspension was checked by a Ford dealer and found to be OK. Posts: 38. Ford Model: Focus Zetec S 1.6 TDCI Ford Year: 2014 UK/Ireland Location: Nottinghamshire . When we hit a rough place in the road, the front end rattles or clunks. What causes a front end clunking noise while driving? Just like the gimbals, the steering part is mobilized when you modify direction. Unbalanced wheels. The 2001 Ford Taurus has 1 problems reported for clunking noise over bumps. 2 answers. It has 27k km on it and it occurs when turning right or going over a bump. Struts, control arms, stabilizer links, stabilizer bar bushings in the front, shocks, upper and lower control arms, stabilizer bar links and bushings and coil springs in the rear. I did this several times with the brake off . 13640 mi. TSB-13-5-11. even the slightest bumps & there would be a knocking noise. PARKING MANEUVERS AND/OR OVER ROUGH. I started noticing noise when going over speed bumps recently as well. 2009 SEL FWD White Platinum 66340 mi. If you hear those annoying clunking noises when going over bumps, it means that something is wrong with the suspension system. Just hit 6,500 miles on my 2018 completely stock RS. The noise happens specifically when one side or the other hits a bump, but I don't believe it happens when both hit at the same time. See all problems of the 2004 Ford F-150 . I just did. I recently (10,000kms ago) replaced a bunch of stuff in the front end due to a loud clunking noise when going over pot holes or . . OP . This did help a fair amount, but, not completely gone. They also found that the offside alloy wheel had a dent so that it did not run true when rotated. I have a 2010 ford focus and when I go over a larger bumps at a medium and faster speed I hear a loud clunk in the left front of the car. 2006 Ford Explorer turns over then starts making clicking noise and completely stops everything. . Front sway bar / ARB bushes tend to go on these and make a clunk on bumps also . The noise happens specifically when one side or the other hits a bump, but I don't believe it happens when both hit at the same time. Jan 7th, 2016 6:08 pm. Someday I'll fix it. Over time the grease will wear away in that small area. My vehicle has over 100,ooo miles. *PE. The consumer was told that Ford had an a camber kit to install to solve the settling. i am getting a clunking noise over small bumps in 2001 ford focus, i have had the car on a lift recently and noticed no loose parts, . (body of the jack is up against the tire) jack up the control arm untill the wheel is off . The noise is much less noticeable outside of the car. . The vehicle experienced extreme shaking from the suspension, and sounded like the wheels were falling off. Rattle/Clunking in front when hitting bumps--dealer unsure.. 8 posts Page 1 . If this is your situation, the parts that may have been affected by usual wear and tear or impacts (e . Just bumpy roads . After changing ball joint there was a minor improvement but it has returned to normal now after a week. After it was fixed, I found that the vehicle got eerily quiet- there had been a low level of clanking at all times that I had attributed to stiff suspension. . btw, here is a picture to illustrate: The stabiliser (anti roll) bar is the horizontal black bar in the picture. I am getting a clunking noise over small bumps in 2001 ford focus, i have had the car on a lift recently and noticed no - Answered by a verified Ford Mechanic . Took the car back to dealership and they removed the struts and replaced both the left and right side bearing plates (brackets). Otherwise when driving no sound can be. It only makes the noise when going over small bumps like lane markers and when going straight. Another potential cause for clunking is . 1 helpful. These are the areas to check the next time you hear these sounds on the road. Its a quick fix if they have the part in stock. It's hard to pin down exactly where it comes from. 66960 mi. Clunking noise when driving over bumps or dips. 5. My original theory of it being caused by axle wrap is seeming less plausable. Watch more videos from 1A Auto. hmmm! Clunking Noise in Ford Focus. Its probablly ball joints. I took the car out for a 5 minute drive to the shops and noticed that whenever I went over a bump or steered slightly, I'd hear a banging sound from inside the car. It's not noticible at high speeds. The leading cause of vibration in Ford Focus when driving at high . C $174. It comes from the front driver's side, and it is. When making a left turn over bumps on the road, I hear a knocking sound in the right front. I heard the clank on certain pothole-like jarring. When making a left turn over bumps on the road, I hear a knocking sound in the right front. With that said, the bushings are wear items and will eventually need to be replaced. At low speeds when you go over a bump or speed ramp, there's a clunking noise coming from under the car. This noise is driving us bonkers. The problem is that the only time it ever makes noise is when going over steep bumps and never while making a turn Worn Ball Joints. It corrects the noise problem, and a lot more. . . All the bells and whistles. Go for brief and careful drive over some bumps. I disassembled the front end and removed the struts to check them out and retighten everything. Either way, worn out or damaged control arms can cause the wheels to move out of alignment, producing a clunking noise going over bumps. Since the suspension system includes various parts, any of them could be faulty. I have taken it in three times and the mechanic cannot figure out where the clunking is coming from. Ford Focus RS Forum. What's the matter? The vehicle had a noise in the rear end, due to tire cupping. I am getting a clunking noise from what sounds like the rear suspension. And the issue only occurred on the right side of the car towards the front and transmitting sound toward the center of the passenger side.